Yellow Stained Bullnose Travertine Tiles Rejuvenated in Pateley Bridge


The photos below show a beautiful Bullnose Travertine tiled kitchen floor at a property in Pateley Bridge which needed professional attention as a consequence of being protected by a cheap and ineffectual sealer.

The problem was that sealer that had been applied did not provide resistance to UV rays, and the exposure to the sunlight had turned the Travertine tiles an unnatural yellow colour. Over time the sealer had gradually worn away in the busiest areas, so it was less noticeable but of course without the protection of the sealer the stone then became exposed to ingrained dirt and stains.

Bullnose Travertine Before Cleaning Patley Bridge Bullnose Travertine Before Cleaning Patley Bridge

I took some pictures however they don’t really show the problems that well but needless to say, the property owner was very keen to have the situation rectified – which of course is where I came in. I travelled to Pateley Bridge, a small market town in Nidderdale in the Borough of Harrogate, North Yorkshire.

What is a ‘Bullnose’ tile, you say? Well, it simply refers to the trim of the tile. While traditional tiles will have a straight edge, a Bullnose tile will have a slightly rounded or curved edge.

Cleaning Yellow Stained Travertine Tiles

To begin the restoration, I deep cleaned the tiles mechanically using Tile Doctor diamond burnishing pads starting with a coarse grit. These pads served the purpose of grinding away the very top damaged layer of the stone, effectively removing the yellow staining, grease marks and any old sealer. You use a little water to help lubricate the process and this soon becomes soiled and needs to be rinsed away and removed after each pad is applied.

Next, I cleaned all of the stained grout lines by hand. I did this using Tile Doctor Pro-Clean, which is a reliable, alkaline-based cleaner for use on both natural stone tiles and grout. I mixed the Pro Clean into a solution of one part cleaner to three parts fresh water and worked it in by hand using a stiff brush along the grout lines. Once done the now dirty cleaning solution was rinsed off the floor and extracted leaving the grout fresh and clean.

Bullnose Travertine During Cleaning Patley Bridge

To finish the cleaning process, I polished the floor with a 3000 grit (very fine) burnishing pad to leave the tiles with a silky satin finish. This pad is applied mechanically with a little water in a technique we often call a spray burnish.

Sealing a Travertine Tiled Kitchen Floor

Once the floor was dry it needed protecting to ensure that dirt could no longer penetrate the pores of the stone. So to guarantee that this wonderful satin finish would last, I sealed the tiles with two coats of Tile Doctor Ultra-Seal.

Ultra-Seal is Tile Doctor’s premium impregnating sealer which is formulated to provide maximum stain protection, especially in food preparation and serving areas such as the kitchen.

Bullnose Travertine After Cleaning Patley Bridge Bullnose Travertine After Cleaning Patley Bridge

The photos above show the outcome of the restoration, I appreciate my photograph skills are not the best but hopefully you can notice how much healthier the stone looks now, compared to the yellow, sickly appearance of the stone before.
 
 

Professional Renovation of a Bullnose Travertine Tiled Floor in North Yorkshire



Source link

Tumbled Travertine Kitchen Tiles Rejuvenated in Lower Boddington


Some of the world’s best-known Travertine quarries are found in Italy. In fact, the curved columns of the Vatican City are made from Travertine. But the stone is popularly used for flooring in many other countries, including the UK. It’s a form of Limestone which is quite soft and porous, but has unique aesthetic characteristics, including natural pits and voids.

The natural process of corrosion, known as pitting, makes it so that without the right maintenance and adequate sealer, Travertine is very difficult to clean. The small holes that form in the stone can quickly become ingrained with dirt and other muck. Making things worse, many modern cleaning products are not suitable for use on Travertine: they are acidic and over time will cause further corrosion to occur.

Recently, I was called to a property in the quaint Northamptonshire village of Lower Boddington to rejuvenate a tumbled Travertine tiled kitchen floor. The house was a very busy one, with children and dogs running around. Needless to the say the tiles were looking worse for well and were in desperate of restoration, including cleaning, polishing and sealing to brighten the appearance of the floor and protect it from everyday stains and foot traffic.

Tumbled Travertine Kitchen floor Before Cleaning in Lower Boddington Tumbled Travertine Kitchen floor Before Cleaning in Lower Boddington

Cleaning and Polishing Tumbled Travertine Kitchen Tiles

The first thing I needed to do was to remove the plinths from the kitchen units and cover the base units and appliances with a protective film to prevent them from encountering the cleaning products.

Next, I began the process we know as burnishing, which involves the application of diamond encrusted burnishing pads to the tiles to resurface and polish them. In the Tile Doctor system, there are four such pads, each possessing a different level of grit. These pads are fitted to a rotary scrubbing machine and then applied sequentially, starting with the Coarse pad, before moving through to the Medium, Fine, and Very Fine.

A small amount of water is used as lubrication with each pad and I stopped in this case between the application of each pad to soak up any excess moisture using a wet vacuum. The result after completing the burnishing process is a very refined and high-quality polished finish.

After burnishing the tiles, I followed by cleaning the grout lines carefully using a combination of handheld brushes and Tile Doctor Pro Clean, which is an alkaline-based tile and grout cleaner.

Sealing Tumbled Travertine Kitchen Tiles

I left to the floor to dry out completely overnight and would return the following day to carry out a final polish of the tiles and to seal the stone. I did this using two coats of Tile Doctor Ultra-Seal, which is a natural-look, impregnating sealer designed to provide maximum protection. You can see the fantastic results in the photos below.

Tumbled Travertine Kitchen floor After Cleaning in Lower Boddington Tumbled Travertine Kitchen floor After Cleaning in Lower Boddington

Before leaving my very happy customer to the enjoy, I left her with customer with a complimentary bottle of Tile Doctor Stone Soap, a neutral and highly reliable cleaner for natural stone floors such as Travertine. This will assist her in maintaining the appearance and condition of the tiles going forward. Another satisfied customer!
 
 

Professional Tile Cleaning, Polishing and Sealing for a Tumbled Travertine Tiled Kitchen Floor Restoration in Lower Boddington



Source link

Dull Travertine Tiles Polished and Sealed in Durham


It can be very frustrating to put effort into regularly cleaning natural stone floor tiles without achieving effective, long-lasting results. This recent customer of mine, who lives in the beautiful city of Durham in north east England, had attempted to maintain the appearance of her Travertine tiled living room floor but it had, nonetheless, become dull and lifeless in many areas.

Travertine Floor in Durham Before Cleaning

The customer’s choice to use a steam mop regularly had caused more harm than good, as the steam damaged the sealer and exposed the stone to ingrained dirt and stains. I was asked to restore the floor back to its original condition and provide advice on the correct cleaning techniques and products for aftercare.

Travertine Floor in Durham Before Cleaning

Cleaning a Dirty Travertine Tiled Living Room Floor

To begin the restoration, I used our Tile Doctor burnishing system, which consists of applying four different diamond encrusted pads to restore the sheen to the stone and rid it of any dirt. Starting with a Coarse grit pad to grind away the dirty layer, I subsequently moved on to the Medium and Fine grit pads to gradually polish the floor. Each pad is applied with water to help lubricate the process and the resultant soil is rinsed off after each pad application.

Next, I cleaned the grout carefully using Tile Doctor Pro-Clean with a stiff grout brush, Pro-Clean is a strong alkaline cleaner that works really well on grout. The floor was left to dry overnight.

Returning the following day, I applied the fourth and final burnishing pad which is a Very Fine 3,000 grit to achieve the best possible sheen. Water is liberally spayed onto the tile during the application of the last pad in what we call a Spray Burnish action.

Sealing a Travertine Tiled Living Room Floor

The final step of the restoration was to seal the tiles. I did this using two coats of Tile Doctor Colour Grow, our impregnating sealer which not only protects the stone, but also rejuvenates its appearance and colour. I then gave the floor another quick buff with a white buffing pad for good measure.

After completing the work, I gave the customer some advice on aftercare. I recommended that she use Tile Doctor Stone Soap in combination with warm water for future cleaning as it is not only reliable, but also helps to maintain the natural patina of the stone. The solution should be gently mopped onto the floor.

Travertine Floor in Durham After Cleaning Travertine Floor in Durham After Cleaning

As you can see from the after photos, the work made a huge difference to the appearance of the Travertine tiles and the customer was very happy with the finished result.

Travertine Floor in Durham After Cleaning
 
 

Professional Tile Cleaning, Polishing and Sealing for a Dirty and Dull Travertine Living Room Tiled Floor Restoration in Durham



Source link

Travertine Wet Room with Leakage Problem Restored in Harrogate


Travertine is a distinct and highly aesthetic material which offers unique characteristics and colouring that not many other types of stone can offer. It looks great when used on tiled floors and in this case shower cubicles however like any natural stone it does need maintenance.

Travertine WetRoom Harrogate Before Cleaning

A good example of this point was this Travertine wet room in Harrogate, which comprised of large format Travertine tiles on the floor and Travertine mosaic tiles on the walls. It was in poor condition and to make things worse had been leaking for years. A local plumber had tried to resolve the leak, but to no avail. At this point, the property owner was desperately searching for a solution, and decided to contact me to see what could be done both to restore the appearance of the wet room and fix the leakage.

Travertine WetRoom Harrogate Before Cleaning

Cleaning a Travertine Tiled Wet Room

On first inspection of the wet room, l couldn’t see any obvious problems that might be causing the leak, however the white silicon did look a bit questionable and had already decided that would need replacing. To start I turned my attention to cleaning the whole shower cubicle, including the tile and grout.

I did this by applying Tile Doctor Pro-Clean, which is a high alkaline cleaner, to remove the mould, soap scum and dyes caused by daily exposure to acidic soap and shampoos. These issues can build up exceptionally quickly if care is not taken to regularly rinse down the shower after each use.

During this process, I noticed grout haze had been left on the surface of the tiles following installation and so treated the problem with Tile Doctor Acid Gel, which is a blend of hydrochloric and phosphoric acid in gel form. Being a gel, this product works particularly well on vertical surfaces because it is easier to control.

The next step was to resolve the leakage problem, starting by removing all the old and unattractive white silicon. When l removed the silicon, I could see that it was black with mould at the back. It was clear to me then that water was getting behind it and this was the cause of the leak. Also, this revealed a 2-3mm gap between the wall and the base of the shower. The gap was damp and mould had collected there, so this needed to be scraped out manually and the gap dried with a heat gun. Finally, l filled the gap with grout to seal it and left the wet room to dry overnight.

Travertine WetRoom Harrogate Before Cleaning

Sealing a Travertine Tiled Wet Room

The next day, I returned to the property and sealed the grout with Tile Doctor Ultra-Seal. This is a premium, natural-look, penetrating sealer formulated to provide maximum stain protection and allow moisture vapour transmission. To finish the restoration, I applied fresh, clear silicon around the base.

Travertine WetRoom Harrogate After Cleaning

In my opinion, white silicon should never have been used with stone, as clear silicon is far more suitable and more pleasing to the eye. Certainly, my customer agreed – and she was very pleased with the result and no more leak.

Travertine WetRoom Harrogate After Cleaning
 
 

Professional Restoration of a Travertine Tiled Wet Room in North Yorkshire



Source link