Victorian Tiled Reception Area Renovated in South Molton Listed Building


I was approached by the owner of a listed Georgian Townhouse right in the middle of the small market town of South Moulton in North Devon who was struggling to have any impact on the appearance of his Victorian tiled reception area, despite hours of back-breaking scrubbing and had become disheartened by it.

Georgian Reception Floor Tiles Before Cleaning South Molton

Upon arrival a survey on the floor was conducted where I tested the moisture level of the tiles because floors of this age and construction didn’t have a Damp Proof Course and as such were just tiled onto whatever subsurface was already there, which quite often contained rubble and other guiding materials such as lime from the construction of neighbouring properties!

Georgian Reception Floor Tiles Before Cleaning South Molton

Whilst talking to the customer he mentioned that he had some old quarry tiles in his kitchen that he also wanted cleaning, however I’ll cover that in another post. To continue I produced a quote for the work which was accepted and a date was agreed for me to return with all the equipment and products required.

Cleaning Victorian Tiled Reception Area

To clean the Victorian tiles in the reception area I applied a medium dilution of Tile Doctor Pro-Clean and left it to soak in for ten minutes. I then set about scrubbing the solution into the tiles using a series of Diamond impregnated burnishing pads ranging from 100-400 grit.

Once the whole floor had been treated in this manner it was thoroughly rinsed with water using a wet and dry vacuum to extract the now soiled cleaning solution and I was able to see that the process had really brought the tiles up a treat.

Concerned about the damp readings I had experienced earlier I decided it would be prudent to give the floor an Acid Rinse with Grout Clean-up to counteract any potential salt issues (efflorescence) that can be a real problem on these old floors which have no Damp Proof Course. I highly recommend this step on old floors as salts can over time permeate through the tiles and the cleaning process draws them to the surface. Left unaddressed the salts can damage the sealer and leave the floor looking far from its best.

Once the tiles had been cleaned, I rinsed the entire floor thoroughly using fresh water to remove any trace of cleaning products, before leaving it to dry off completely overnight.

Sealing an Original Victorian Tiled Hallway and Entrance Lobby

The following day I returned and after rechecking the moisture levels to ensure that they had adequately dried out I started to seal the Victorian tiles in the reception area. To improve colour, I first applied a coat of Tile Doctor’s Colour Grow, a solvent based impregnating sealer which picks out and enhances the natural colour of the tiles, not only bringing the whole floor to life but helping to disguise any damage the floor has suffered over the years. After this coat had dried sufficiency four coats of Seal and Go were applied to finish off the floor and give it that ‘wow factor’.

Georgian Reception Floor Tiles After Cleaning South Molton Georgian Reception Floor Tiles After Cleaning South Molton

The customer was thrilled and left the following feedback on the Tile Doctor feedback system:

“The work was carried out in a professional manner, with excellent results.”

For aftercare I left the customer with some guidance on care and maintenance of the floor as well as a suitable bottle of tile cleaner.
 
 

Professional Renovation of a Victorian Tiled Reception Floor in Devon



Source link

Original Victorian Tiles Restored at B&B in Bude


Bude is a lovely coastal resort in North Cornwall and is home to several B&Bs for visitors to the area. It became popular during the latter half of Queen Victoria’s reign, as sea bathing became a popular trend amongst the upper and middle classes, and as a result there are plenty of period houses.

In fact, I was recently contacted by a lucky Bed and Breakfast owner who had uncovered this late Victorian tiled hallway and entrance lobby which was around a hundred years old during renovation work. It had been under carpet for at least twenty years and had a variety of stains including paint, tar and glue!

The customer rightly wanted to reinstate it as a showpiece to greet clients upon entering the upmarket guesthouse but had no luck trying to remove stains themselves and had spent many hours on hands and knees but to no avail and were nearly ready to take the builder’s advice and cover it in a self-levelling cement and install a carpet throughout which would have been sacrilege!

Victorian Tiled Hallway Before Restoration at Bude Bed and Breakfast

Cleaning an Original Victorian Tiled Hallway and Entrance Lobby

To begin with diamond-impregnated buffing pads were used with a rotary machine to scrub the floor and open up the pores. Small diamond hand blocks were also used to get into those difficult to reach areas such as corners and under the stairs.

Afterwards the floor was thoroughly rinsed with water which was then extracted using a wet vacuum. This was followed by giving the floor an Acid rinse using Tile Doctor’s Acid Gel. This helped to remove old mineral deposits and residue from carpet underlay. I had to be careful not to leave the acid down for too long because these tiles are susceptible to acid damage. This is also a great product to use as par for the course on floors like this that don’t have a damp proof course (floors generally didn’t pre-1950s) and the acid will neutralise any salts coming rising up through the tile later.

Dealing with salt issues on these old floors (efflorescence) is essential because they can damage the sealer or become trapped under it, detracting from the beauty of the floor. Given the age of the house It’s difficult to know what the floor had been laid onto. Often it was compacted rubble and building works from the erection of the adjoining houses. Terraced and some of the later Victorian floors were laid on a wet limecrete scree which contain a high salt-content.

Sealing an Original Victorian Tiled Hallway and Entrance Lobby

Once the tiles had been cleaned, I rinsed the entire floor thoroughly using fresh water to remove any traces of chemicals, before leaving it to dry completely overnight.

Upon my return to the B&B the next day, I sealed the tiles using several coats of Tile Doctor Colour Grow, an impregnating sealer which provides robust protection and intensifies the natural colours in the tile. It does this while leaving a natural-look matte finish which is befitting of a classic Victorian geometric patterned floor like this one.

Now cleaned and freshly sealed, the Victorian tiles will be in a much strong position to cope with the busy B&B season over the Summer. The owner was very pleased and I’m sure visitors to the B&B will be very impressed with this original feature!

Victorian Tiled Hallway After Restoration at Bude Bed and Breakfast

As part of the package a cleaning and maintenance guide is provided once the work has been completed but unfortunately the owner’s uncle didn’t consult this when house-sitting and attempted to clean the floor with white spirit. Fortunately, I was able to return and improve the damage that was caused much to the owner’s relief and just in time for opening!
 
 

Professional Restoration of an Original Geometric Victorian Tiled Hallway at a Bude B&B



Source link