Deep Cleaning Flagstone Flooring in Vines Cross


This customer who lived in the old Sussex village of Vines Cross near Horam, had a lovely Flagstone floor installed in the Kitchen some years earlier but because they wanted a completely natural look no sealer had been applied. With no protection in place dirt had become ingrained into the pores of the stone over time making it dull and difficult to clean effectively.

Flagstone floor before restoration Vines Cross

Their beautiful flagstone floor no longer looked as it should and the owner of the house was keen to have it deep cleaned and looking its best again. I was happy to do the work and before starting I made sure to discuss the topic of sealing and recommended one called Tile Doctor Ultra-Seal which is a natural look sealer that doesn’t change the look of the stone yet protects it from dirt becoming ingrained.

Flagstone floor before restoration Vines Cross

Deep Cleaning a Lapicida Sandstone Floor

With no sealer evident on the stone there was no need to use a coatings remover on the tiles, so after protecting the Kitchen units and skirting board with plastic tape I started with a combination of Tile Doctor Pro-Clean tile and grout cleaner mixed with a small amount of another Tile Doctor product called NanoTech HBU. HBU stands for Heavy Build-Up and this product utilises nano-sized abrasive particles to assist in the cleaning process.

The solution was left to dwell and soak into the stone for ten minutes before being scrubbed in using a rotary buffing machine fitted with a black pad. With the cleaning solution on the floor I also took the time to run a stiff brush along the grout lines to make sure they were also scrubbed clean. After a while the cleaning solution became dirty with all the soil that was being released from the tile and was then extracted using a wet vacuum. The floor was then rinsed with water and stubborn areas re-treated using the same process until I was satisfied it was thoroughly clean.

Flagstone floor during restoration Vines Cross

After giving the floor a final rinse and drying it as much as possible with a wet vacuum it was left to dry off fully overnight.

Flagstone floor during restoration Vines Cross

Sealing a Flagstone Floor

I returned the next day to seal the floor first checking it for dampness using a damp meter. All was well, and the flagstones were dry, so I was able to proceed with sealing the stone.

As I mentioned earlier my client liked the natural look but having experienced the problems of maintaining an un-sealed floor had agreed for me to seal it with Tile Doctor Ultra-Seal. I applied a single base coat of Tile Doctor Ultra Seal as agreed and then recommended that we add a coat of Tile Doctor Seal and Go as well, just to brighten up the floor and add a slight sheen.

Flagstone floor after restoration Vines Cross

I knew from experience this would work well on Flagstones and my client was happy to trust me. As suspected the combination of the two sealers was a winner and my client was overjoyed with the resulting effect and more so that she can now maintain it satisfactorily.

Flagstone floor after restoration Vines Cross
 
 

Deep Cleaning a Flagstone Kitchen Floor in East Sussex



Source link

Dull Sandstone Kitchen Tiles Revitalised in Quarry Bank Mill


Quarry Bank Mill is an old textile mill just outside of Wilmslow in East Cheshire that dates back to the Industrial Revolution when it was used to produce cotton. The mill is now under the care of the National Trust who recently put together a £9.4 million project, supported by the Heritage Lottery Fund the further restoration of the mill and its gardens.

The 18th century mill is now a popular attraction and I was recently asked to clean and seal the Sandstone flooring in the Kitchen of the head gardeners cottage. The cottage is actually located in the formal gardens which were recently visited by HRH Price of Wales.

Sandstone Kitchen Floor Tile Before Cleaning Quarry Bank Mill Cottage

The Sandstone Kitchen floor was in good physical condition so unlikely to be the original however like any stone floor in constant use the sealer was wearing off and dirt was becoming ingrained in the pores of the stone detracting from its overall appearance.

Sandstone Kitchen Floor Tile Before Cleaning Quarry Bank Mill Cottage

Cleaning Dirty and Dull Sandstone Flagstones

Our first job was to protect the wooden kitchen units and other woodwork with tape. Next I set about cleaning the Sandstone and stripping any reaming sealer off in the process. To do this I applied a strong dilution of Tile Doctor Remove and Go, which is multi-purpose stripper and cleaner. The product strips away any old sealer on the tiles and draws out ingrained dirt, stains and heavy grease build-up.

I applied the product and left it to soak for roughly fifteen to twenty minutes to allow time to break down the old sealer and penetrate the pores of the stone to reach any embedded dirt. Next, I scrubbed the floor using a specialised buffing machine fitted with a black scrubbing pad swelled with water to get the stone clean. The resulting dirty cleaning slurry was quickly soaked up using a wet vacuum and after rinsing with water With the floor clear I was able to spot stubborn areas that need more work and repeated the process.

With the stone clean I turned my attention to the grout lines and scrubbed in a strong dilution of Tile Doctor Pro-Clean which was then rinsed off with water. I then completed another spot check of the floor whilst using the wet vacuum to get the floor as dry as possible. With the cleaning part of the job complete I left for the day to allowing the floor to dry off fully overnight.

Sandstone Kitchen Floor Tile After Cleaning Quarry Bank Mill Cottage

Sealing Sandstone Kitchen Tiles

Upon returning to the property the following day, I tested the floor with a damp meter, checking for any excess moisture that could prevent me from sealing the stone. The floor proved dry and so I began to seal the Sandstone starting with a single coats of Tile Doctor Colour Grow. Colour Grow is an impregnating sealer that is designed to fill the pores of the stone blocking dirt from becoming ingrained there whilst enhancing the natural colours in the stone at the same time.

Once the Colour Grow was dry I followed with the application of five coats of Tile Doctor Seal and Go which is a compatible water-based acrylic sealer which provides both a stain resistant surface seal and a durable low-sheen finish.

Sandstone Kitchen Floor Tile After Cleaning Quarry Bank Mill Cottage

The floor now looks much healthier and the new sealer show keep it looking that way for some years to come.
 
 

Professional Renovation of a Sandstone Tiled Floor in Wilmslow



Source link

Old Flagstone Tiled Kitchen Floor Renovated at a Stacksteads Cottage near Backup


The pictures below were taken in the Kitchen of a charming cottage situated in the village of Stacksteads near the town of Backup, North of Manchester in the district of Rossendale. The flagstone floor was over 100 years old and the customer was unhappy with their appearance. They had tried to clean/mill and seal themselves a few years ago and had found the process hard work and very time consuming. This time round they decided to ask professional applicator at Tile Doctor for help.

Old Flagstone Tiled Kitchen Floor Before Renovation in Stacksteads Backup

We had conducted a small patch test so we could show possible results to the customer. They had also advised us that they felt the stained areas of grout was beyond cleaning and would probably need replacing. However replacing the grout would have been quite an expensive option so instead of replacing we suggested deep cleaning the grout lines during the renovation process.

Old Flagstone Tiled Kitchen Floor Before Renovation in Stacksteads Backup

The customers were happy with the results of the patch test so the job was booked in.

Deep Cleaning Old Flagstone Flooring

On our return visit we set about deep cleaning the flagstones using a strong dilution Tile Doctor Pro-Clean worked in using a Black Scrubbing pad fitter to a rotary cleaning machine. This action certainly gave the floor a good clean and removed the old sealer but some stains were proving stubborn to shift so we tried a stronger product called Remove and Go combined 50/50 with NanoTech HBU which add nano-sized abrasive particles to the mix.

We left the resulting formula to soak into the stone for a while and then scrubbed it into the floor with a stiff brush paying particular attention to the grout lines. This did the trick and so we then removed the now soiled and dirty cleaning products with a wet vacuum and washed down the floor with clean water to remove any trace of product and neutralise the floor before sealing. We then left for the evening so the floor could dry out fully overnight.

Old Flagstone Tiled Kitchen Floor During Renovation in Stacksteads Backup

Sealing a Flagstone Tiled Kitchen Floor

We came back the next day and tested the floor with a damp meter in a few different locations to make sure no dampness remained in the stone. The Flagstone was dry so we proceeded to seal the floor with a couple of coats of Tile Doctor Colour Grow which penetrates into the pores of the stone protecting it from within and enhancing the natural colours of the stone.

Old Flagstone Tiled Kitchen Floor After Renovation in Stacksteads Backup

The beautiful colours of blue and dark sand were showing after sealing with Colour Grow which is the best sealer for stone floors. Certainly the customer was very happy with the results and left the following 5 star review!

We could not praise Kamila enough. Our flagstone floor was in desperate need of some TLC. She was punctual, thorough and completely professional. Throughout the whole process she invited me to see the progress and to keep me informed of what she was doing. She also gave us good advice on how to clean and care for our stone floor. The end result is fabulous and we are absolutely delighted. We would definitely recommend Kamila to anyone.
Jo H, Bacup

Old Flagstone Tiled Kitchen Floor After Renovation in Stacksteads Backup
 
 

Old Flagstone Kitchen Floor Cleaned and Sealed in South Lancashire



Source link

Old Flagstone Tiled Flooring Resurfaced in Great Harwood


This customer in Great Harwood was so fedup with their Flagstone tiled flooring on the ground floor of their property. In fact they were ready to take up the floor, put a new concrete base in place and lay a wood floor down on top. However this is the original floor from when the house was built in 1894 so was not replaceable as such, and the customer really wanted to restore the floor back to its original condition, as well as other material’s in the house, to recreate the Original Victorian feeling that had been missing for many years.

Flagstone Floor Before Restoration Great Harwood Flagstone Floor Before Restoration Great Harwood

We have completed quite a lot of this type of work for customers in the past and we publish all out work on our website and it was one job similar to this that convinced the customer that we had the answer to her problem.

Milling an Old Flagstone Floor

A few years ago Tile Doctor invented a system called Milling to deal with problematic stone floors like this one. The system uses very coarse Diamond pads fitted to heavy machinery to mill the stone until it is a smooth as possible. This action gets rid of years of traffic marks, ingrained dirt as well as old wax and sealers. There’s nothing harder than Diamond so we find this system woks really well on an old damaged floor like this one.

The process will leave the stone looking rough so once finished with the coarse pads we then apply a lighter Diamond grit pad to remove the scratch marks that the heavy diamond grits leave behind. The floor is rinsed between pads and a little water is also used to provide lubrication.

After resolving the stone issues we re-grouted the whole floor and conduct one more final clean using Tile Doctor Neutral Clean before leaving it to dry out ready for sealing a few days later.

Sealing an Old Flagstone Floor

On our return the sealer we chose for these old flagstone was Tile Doctor Colour Grow, it penetrates into the pores of the stone protecting it from within and in the processes lift the natural colours in the Stone.

Colour Grow is a breathable sealer which you need when sealing these old stone floors which won’t have a damp proof membrane installed. A wet look or polishing sealer will eventually spoil in damper wetter weather.

Another advantage of Colour Grow is it leaves a Matt finish which is a more natural look for Sandstone Flagstones like these. They will also be easier to clean as the milling process made the stone much smoother to the touch, so it becomes a lot easier to maintain in the future.

Flagstone Floor Before Restoration Great Harwood Flagstone Floor Before Restoration Great Harwood

The results were fantastic, and the customer is really pleased that they will no longer have to replace the tiles. The appearance and condition of the Flagstone had been improved so much that most people would not believe it had been laid 123 years ago!
 
 

Restoring an Old Flagstone Floor in Lancashire



Source link

Old Blue Lias Flagstone Kitchen Floor Restored and Sealed in Odcombe, Somerset


This post comes from the kitchen of a house in the village of Odcombe, which is a few miles west of Yeovil, where the Blue Lias Flagstone floor which dated back to 1780 was far from looking its best. With the exception of ingrained dirt the Flagstones were in good physical condition considering their age but the some of the grouting had come loose and would need replacing as part of the restoration process.

Blue Lias Flagstone Kitchen floor in Odcombe Somerset Before Restoration

If left unprotected dirt becomes ingrained into the pores of stone and once this happens it can become very difficult to keep it clean. A sealer will add that layer of protection but does wear off over time and in this case I suspect it had been quite some time since the floor had been given a deep clean and re-seal.

Deep Cleaning Blue Lias Flagstones

To deep clean the floor we spent two days scrubbing the floor with Tile Doctor Pro-Clean which is a multi-purpose cleaner/sealer remover that’s designed for use on Tile, Stone and Grout. The product is diluted with water and then applied to the floor where it is left to soak into the stone for ten to twenty minutes before scrubbing the floor with a rotary machine fitted with a scrubbing pad. This process released the dirt from within the pores of the stone and we were able to rinse it away with more water which was extracted using a wet vacuum.

The process was repeated a couple of times to ensure the stone was as clean as it could be and we used stiff brushes along the grout lines where the pad struggled to reach to ensure the grout was also clean.

One done our attention turned to raking out loose grout and replacing it with new in a matching colour to ensure it blended in with the old.

Blue Lias Flagstone Kitchen floor in Odcombe Somerset Before Restoration

Sealing Blue Lias Flagstones Floor Tiles

We left the floor to dry for a further two days before returning to apply a sealer, it’s important that the floor is dry before sealing as applying a sealer to a damp floor will can have undesirable results.

After the deep cleaning process, the Flagstones were looking cleaning but rather grey so before sealing and to bring the colour back two coats of Stone oil were applied and left to soak in.

Once the Stone Oil had dried it was followed by sealing the floor with Tile Doctor Seal and Go which is a water based sealer (so no smell as it dries) that leaves an appealing satin sheen lifting the appearance as well as protecting the stone.

Blue Lias Flagstone Kitchen floor in Odcombe Somerset After Restoration

It took some time to do but I think you will agree this two-hundred-year-old floor has been transformed by the process.

Blue Lias Flagstone Kitchen floor in Odcombe Somerset After Restoration
 
 

Restoring the Appearance of a Sandstone tiled floor in Somerset



Source link