Very Dirty Quarry Tiled Kitchen Floor Restored in Rotherfield


Looking at the pictures below you might think this Quarry Tiled kitchen floor at a cottage in Rotherfield was as old as the village which dates back to the 8th Century and is mentioned in the Doomsday book. It really was in a bad state with I don’t know what covering the tiles which had gone black as a result but were actually very pretty as you will see later.

The client was having a new kitchen fitted and wanted the tile and grout restored so as not to incur the cost of replacing it. This really is the best time to look at getting your tiles thoroughly cleaned as with many of the old units removed I could access most of the floor and of course I didn’t need to worry about protecting the units either.

Dirty Quarry Tiled Kitchen Floor Before Cleaning Rotherfield

Cleaning Dirty Kitchen Quarry Tiles

I could see this floor was going to be a challenge so decided to try a strong cocktail of Tile Doctor Pro-Clean and Nanotech HBU, HBU stands for Heavy Build-Up so quite appropriate I thought. Working in sections the floor was soaked in the cleaning cocktail and left to dwell for some time in order to soften the dirt and grime.

Dirty Quarry Tiled Kitchen Floor During Cleaning Rotherfield

The next step was to run over the tiles with a set of Burnishing pads which are encrusted with industrial diamonds. It took more than one attempt at this process but the abrasive pads had the desired effect and eventually revealed the beautiful quarry flooring below.

Dirty Quarry Tiled Kitchen Floor During Cleaning Rotherfield

The pads are effective on the tiles but the grout sits a little lower and so to reach these a stiff brush was scrubbed into the grout by hand.

To remove the dirt that was released from the cleaning process and further clean the tiles I used a Spinning Tool through the process. The tool is powered from a large compressor that sits in my van which forces hot water under pressure onto the tiled floor whilst simultaneously extracting the dirty water back to a tank on the van. It’s an amazing tool that is very effective however you do need to have the van parked very close the house due to a limitation on the hose lengths.

Dirty Quarry Tiled Kitchen Floor During Cleaning Rotherfield

With the tiles now clean and rinsed with water the floor was dried as much as possible with a wet vacuum.

Sealing Kitchen Quarry Tiles

The floor was left to dry for a couple of days before I returned to complete the restoration with the application of a sealer. I tested the floor with a damp meter on my return to ensure it was dry; all was well so I moved onto sealing. Sealer of choice on this occasion was Tile Doctor Seal and Go which is a water-based sealer which so it doesn’t leave a smell as it dries. The Quarry tiles were quite porous, which is not uncommon for Quarry Tiles and six coats of sealer were required in the end.

Dirty Quarry Tiled Kitchen Floor After Cleaning Rotherfield

As the photographs show, the floor was transformed and my customer was elated with the results saying “wow it’s like new!”

Dirty Quarry Tiled Kitchen Floor After Cleaning Rotherfield
 
 

Professional Restoration of a Dirty Quarry Tiled Floor in East Sussex



Source link

Lower Courtyard Slate Patio Cleaning in Brighton


Brighton is a great location to work with a huge variety of property styles and tile installation but being such a popular location parking can be an issue. We need to park our van physically close to the property so we can make use of our powerful Truck mounted cleaning system that weighs in at 3/4 of a tonne! It’s a really clever system that uses water under very high pressure to clean the stone whilst at the same time recovering the waste back to a storage tank in the van making it a very clean operation even in the most awkward conditions.

I thought I would mention this first as I was asked to deep clean and seal the lower ground level Slate tiled courtyard patio at this property in Brighton which was located down a small side street where people rarely moved their vehicles due to lack of spaces available. Fortunately I was aware of the issue and managed to overcome it by arranging a parking suspension with Brighton and Hove City Council allowing me to park my van.

Slate Patio Courtyard Brighton Parking Suspension Slate Patio Courtyard Brighton Before Cleaning

This patio was open to the elements and was also used by the owner’s dog. Further due to its inaccessibility it had never been cleaned apart from with the general hosepipe sprayer. Any kind of porous stone will over time become dirty and stained if the sealer is not maintained, sealers do fail eventually and usually in the highest traffic areas first where they become worn down the most.

Slate Patio Courtyard Brighton Before Cleaning Slate Patio Courtyard Brighton Before Cleaning

Deep Cleaning Dirty Slate Patio

The first job was to pressure clean the entire area using the truck mounted system I mentioned earlier, it works well on patios removing all sorts of detritus that can build up over time.

With patio now clear I was able to see the condition of the slate which showed grout smears on the surface from installation as some stubborn staining that the pressure treatment had been unable to shift. To resolve this I mixed up a batch of Tile Doctor Cleaning Agent Oxy Gel together with Tile Doctor Acid Gel and applied it to all the problem areas. Liquids have a tendency to run (patios have a gentle slope to allow for rain run off) whereas Gel’s remain in place so they dwell on the problem areas longer and really get to work. I left the mixture in place for a short while before scrubbing it in with a stiff brush and then extracted it using truck mount system. The water from the truck mount also neutralised the acid which is important as you shouldn’t leave acid on natural stone for too long.

Slate Patio Courtyard Brighton During Cleaning Slate Patio Courtyard Brighton During Cleaning

Sealing a Slate Patio

Fortunately there was no rain that night and being August also quite warm so I was pleased to find the Slate had tried off fully by the next day when we returned to seal it. To be certain however I ran some quick damp tests to check that the floor was completely dry and ready to be sealed. Once satisfied, I applied a couple of coats of Tile Doctor Colour Grow which works really well on Slate giving it that much needed protection against dirt and stains, along with a full lustre finish that enhances the character of the floor.

Slate Patio Courtyard Brighton After Cleaning Slate Patio Courtyard Brighton After Cleaning

The client was elated both with the result and even more so after we explained how to maintain the look of the tiles with having a doggy in the house!

Slate Patio Courtyard Brighton After Cleaning
 
 

Refurbishing a Slate Tiled Patio in East Sussex



Source link