Deep Cleaning, Sealing and Polishing 120m2 Limestone Tiled floor in Biddenham


The client from the Bedford village of Biddenham had requested a quote to restore the look of their Limestone floor tiles which were laid throughout the whole ground floor including lounge, hallway and kitchen covering approximately 120m2 in total. The floor needed a thorough clean, filling of holes in high traffic areas followed by polishing and then sealing.

Limestone Tiled Lounge Floor Before Cleaning Biddenham

Over time, the floor in this busy household with 2 large dogs had become dirty and certainly worse for wear with all the use it had been getting. A quote was given and accepted and work was booked in to be carried out over 4 days with 2 Tile Doctor technicians on site for 2 of those days.

Limestone Tiled Kitchen Floor Before Cleaning Biddenham

Deep Cleaning Limestone Floor Tiles

We returned on the agreed date and started work to get this floor back to looking its best. My initial task before beginning the cleaning process was to apply a protective wrap around the oak doors and moving heavy furniture with sliders that the client couldn’t move themselves to give us a clear area to work in.

Limestone Tiled Hallway Floor Before Cleaning Biddenham

We then applied Tile Doctor Pro-Clean, diluted with water, to the floor. Pro-Clean is a strong alkaline cleaner that is suitable for use on all natural stone floors such as Limestone, Slate and Travertine.

After leaving the solution to dwell for a few minutes, We began to scrub over sections (Approximately 10m2 at a time) with a 17” scrubbing pad fitted to a buffing machine, whilst helping to remove a lot of the built up dirt on the surface of the tiles, the products also stripped off the old sealer, this was then rinsed and removed using a wet pick up machine. Following this we paid special attention to the grout lines, scrubbing with grout brushes and Tile Doctor Grout Clean-Up.

After completing the cleaning, I rinsed the floor again with clean water to remove any excess cleaning products. I then began to burnish the floor using Tile Doctor Diamond encrusted burnishing pads. This was done in four steps, as I used four different pads (coarse, medium, fine and very fine) rinsing the floor with water between each pad. Starting with a coarse pad and then gradually working up to the very fine pad achieving a high polish finish in the process. I finished off the process with a quick rinse and a white buffing pad to give the floor a final polish before I commenced the sealing of each area the following day to allow grout and stone to fully dry overnight.

Sealing Limestone Floor Tiles

The client requested a natural look finish so my choice of sealer was Tile Doctor Ultra Seal which will protect the floor but not change the colouring in any way. The sealer penetrates deep into the pores of the stone, providing water resistance and long-term protection from ingrained dirt and stains.

Limestone Tiled Kitchen Floor After Cleaning Biddenham Limestone Tiled Lounge Floor After Cleaning Biddenham

This was a large area so it took some time to complete but it was well worth the effort, certainly the customer thought so and left the following feedback on the Tile Doctor Feedback System.

Phil and his team were polite, friendly and professional at all times. Nothing was too much trouble for them and they worked very diligently to ensure they got the best possible outcome and the floors l. . . ok better than new at the end.

As you can see from the comments the client was extremely happy with the results and he has asked for details of our maintenance plan to keep his floors looking their best for years to come.

Limestone Tiled Hallway Floor After Cleaning Biddenham
 
 

Large Limestone Floor Renovation in Bedfordshire



Source link

Badly Stained and Pitted Tumbled Travertine Kitchen Floor Renovated in Clophill


Travertine floor tiles are very appealing but without the protection of a sealer they will soon suffer, fortunately this can be remedied as demonstrated in these pictures of a Tumbled Travertine floor at a house in the Village of Clophill in the Flit River Valley South of Bedford.

This customer had called me out as her ten year old floor was looking very sorry for itself and she was concerned that a lot of holes were appearing which was making cleaning of the floor difficult as dirt was getting trapped in the holes. I went over and carried out a test clean on two separate tiles in the kitchen and the customer was amazed at how clean they came up and especially the grout. An appointment was made for the next month and work commenced.

Tumbled Travertine Kitchen Floor Before Cleaning Clophill Village

Cleaning a stained Tumbled Travertine tiled floor

The first thing we do is to protect the lovely Oak kitchen units by removing plinths, covering base units and appliances with a protective film. We then commenced work by burnishing the stone with a set of Tile Doctor Diamond encrusted burnishing pads. The pads are applied individually to each tile in sequence starting with a coarse pad and finishing with the fine pad which brings up the polish. A little waster is used to lubricate the process along the way and the floor is rinsed in-between each pad with the resulting residue extracted from the floor using a wet vacuum. The process takes quite some time but the results are well worth the effort.

Tumbled Travertine Kitchen Floor Before Cleaning Clophill Village Tumbled Travertine Kitchen Floor Before Cleaning Clophill Village

Once this was done our attention was turned to the grout which being recessed is difficult to reach by with pads. So for the grout a medium dilution of Tile Doctor Pro-Clean is applied to the grout lines and scrubbed in with stiff brushes by hand.

The floor was rinsed again and fans were used to assist drying before filling the holes with the same filler the customer had used previously to match the colour of the stone as much as possible.

Sealing a Travertine tiled floor

When we returned the next day the floor had dried and we were able to give the floor a final polish with a very fine burnishing pad. The floor was then sealed with two coats of Tile Doctor Ultra Seal which provides excellent protection without changing the colour of the stone to provide a natural look.

Tumbled Travertine Kitchen Floor After Cleaning Clophill Village

My customer was delighted with the results and kindly left the following testimonial on the Tile Doctor Feedback system.

“We had several rooms of very dirty travertine tiles that were deep cleaned, filled and re sealed. The floor now looks amazing. Fantastic job by a professional and friendly team.”

Tumbled Travertine Kitchen Floor After Cleaning Clophill Village Tumbled Travertine Kitchen Floor After Cleaning Clophill Village

 
 

Stained and Pitted Travertine Kitchen Floor Restoration in Bedfordshire



Source link

Restoring the Spoiled Appearance of a Sandstone Tiled Patio in Bedford


This is the ideal time of year for property owners to not only think about restoring their internal natural stone floor tiles, but also their external tiles. With it being Summer, the weather is warm and dry enough for patio restorations to take place.

The photographs below show a recent restoration of a two-year old Sandstone tiled patio at a property on a new build development in Bedford, the country town of Bedfordshire. Sandstone is a naturally porous stone, which does make it more vulnerable to the elements when it is used for outside flooring and is not sealed.

Sandstone Patio Bedford Before Cleaning

Unfortunately, the patio had not been sealed when it was first installed, and during the two years since, the combination of damp weather, a lack of sunlight in shaded areas, and a build-up of green staining from moss spores – together with general dirt and grime – had greatly spoiled the appearance of the beautiful stone.

Sandstone Patio Bedford Before Cleaning

Cleaning a Spoiled Sandstone Tiled Patio

My first course of action in carrying out the restoration was to lightly coat the patio with Tile Doctor Pro Clean. This is a multi-purpose, alkaline-based cleaner which is suitable for use on most natural stone, including Sandstone, Granite, Limestone, Slate, and Travertine.

The product was subsequently agitated with a scrubbing brush fitted to a rotary machine, before I pressure washed the patio at a medium pressure to avoid damaging the stone. As you can see from the photos below, this cleaning made a great improvement to the condition of the patio – in fact, it appeared almost new again! The customer was very pleased with the outcome.

Sandstone Patio Bedford After Cleaning

The customer decided not to have the patio sealed, as he preferred the natural look and would prefer to have it cleaned on a yearly basis. Sealing is less important for external tiles, as compared to internal tiles, however if you do decide not to seal your patio, it’s highly recommended that you establish a routine maintenance plan for the stone. Otherwise, you run the risk – after just a few years – of allowing your tiles to end up in a similar condition to this Sandstone tiled patio before it had been restored.

Sandstone Patio Bedford After Cleaning
 
 

Professional Cleaning and Restoration of a Spoiled Sandstone Tiled Patio in Bedford



Source link